R-410AJ**ZJ SERIES 6-1/2 - 12-1/2 Ton60 Hertz 860616-JIM-D-0614TABLE OF CONTENTSGeneral . . . . . . . . . . . . . . . . . . . . . . . . . . .
860616-JIM-D-061410 Johnson Controls Unitary ProductsFigure 9: J12ZJ Physical Dimensions15.2329.0314.8529.0314.8515.2328.86 29.6644.09Ø 24.58 TYP. 4 P
860616-JIM-D-0614Johnson Controls Unitary Products 11Detail ADetail BTable 4: J06 thru 12ZJ Unit Physical DimensionsUnit Model NumberDimension (in.)AB
860616-JIM-D-061412 Johnson Controls Unitary ProductsTOP VIEWFigure 10: J06 thru 12ZJ Unit Bottom Duct OpeningsBottom condensate drainBottom gassupply
860616-JIM-D-0614Johnson Controls Unitary Products 13Figure 11: J06 thru 12ZJ Unit Electrical EntryFigure 12: J06 thru 10ZJ Unit Side Duct OpeningsDis
860616-JIM-D-061414 Johnson Controls Unitary ProductsFigure 13: J12ZJ Unit Side Duct OpeningsFigure 14: J06 thru 12ZJ Unit Left Duct OpeningDot Plugs2
860616-JIM-D-0614Johnson Controls Unitary Products 15Figure 15: J06 thru 12ZJ Roof CurbFigure 16: J06 thru 12ZJ Transition Roof CurbDuctworkDuctwork s
860616-JIM-D-061416 Johnson Controls Unitary ProductsDuct CoversUnits are shipped with the side duct openings covered and a covering over the bottom o
860616-JIM-D-0614Johnson Controls Unitary Products 17designed for HCFC and CFC refrigerants. Take all necessary precautions to avoid exposure of the o
860616-JIM-D-061418 Johnson Controls Unitary ProductsPower Wiring DetailUnits are factory wired for the voltage shown on the unit nameplate. Refer to
860616-JIM-D-0614Johnson Controls Unitary Products 19Thermostat Wiring (Not applicable to units with VFD)The thermostat should be located on an inside
860616-JIM-D-06142 Johnson Controls Unitary ProductsGeneralJohnson Controls J**ZJ units are single package air conditioners with optional gas heating
860616-JIM-D-061420 Johnson Controls Unitary ProductsTable 8: Electrical Data J06 thru 12ZJ Standard Motor - Without Powered Convenience Outlet Size(
860616-JIM-D-0614Johnson Controls Unitary Products 21J10(10)208 16 110 24.9 3.5 6.8 5.5 0.0None - - - 49.8 55.3 60 70E18 13.5 2 37.5 55.3 62.2 60 70E2
860616-JIM-D-061422 Johnson Controls Unitary ProductsJ06 thru 12ZJ Hi Static Motor - Without Powered Convenience Outlet Size(Tons)VoltCompressors(eac
860616-JIM-D-0614Johnson Controls Unitary Products 23J10(10)208 16 110 24.9 3.5 9.6 5.5 0.0None - - - 52.6 58.1 60 70E18 13.5 2 37.5 58.8 65.7 60 70E2
860616-JIM-D-061424 Johnson Controls Unitary ProductsJ06 thru 12ZJ Standard Motor - With Powered Convenience Outlet Size(Tons)VoltCompressors(each)OD
860616-JIM-D-0614Johnson Controls Unitary Products 25J10(10)208 16 110 24.9 3.5 6.8 5.5 10.0None - - - 59.8 65.3 70 80E18 13.5 2 37.5 67.8 74.7 70 80E
860616-JIM-D-061426 Johnson Controls Unitary ProductsJ06 thru 12ZJ Hi Static Motor - With Powered Convenience Outlet Size(Tons)VoltCompressors(each)O
860616-JIM-D-0614Johnson Controls Unitary Products 27J10(10)208 16 110 24.9 3.5 9.6 5.5 10.0None - - - 62.6 68.1 70 80E18 13.5 2 37.5 71.3 78.2 80 80E
860616-JIM-D-061428 Johnson Controls Unitary ProductsTable 9: Physical DataJ06 thru 12ZJ Physical Data ComponentModelsJ06ZJ J07ZJ J08ZJ J10ZJ J12ZJNo
860616-JIM-D-0614Johnson Controls Unitary Products 29CONDENSER FAN DATAQuantity of fans 22224Fan diameter (Inch) 24 24 24 24 24Type Prop Prop Prop Pro
860616-JIM-D-0614Johnson Controls Unitary Products 3Wear safety glasses and work gloves. Use quenching cloth and have a fire extinguisher available du
860616-JIM-D-061430 Johnson Controls Unitary ProductsOptional Electric HeatThe factory-installed heaters are wired for single point power supply. Powe
860616-JIM-D-0614Johnson Controls Unitary Products 31Optional Gas HeatThese gas-fired heaters have aluminized-steel or optional stainless steel, tubul
860616-JIM-D-061432 Johnson Controls Unitary ProductsGas ConnectionThe gas supply line can be routed within the space and roof curb, exiting through t
860616-JIM-D-0614Johnson Controls Unitary Products 33For satisfactory operation, LP gas pressure must be 10.5 inch W.C. at the unit under full load. M
860616-JIM-D-061434 Johnson Controls Unitary Productsthe assembly. Field installed Motorized Outdoor Damper accessories include complete instructions
860616-JIM-D-0614Johnson Controls Unitary Products 35call for Differential Demand Ventilation mode for units installed with economizer option.• APS -
860616-JIM-D-061436 Johnson Controls Unitary ProductsBas-ready VFDFactory-installed VFD is also available with 'BAS-Ready' models. Terminal
860616-JIM-D-0614Johnson Controls Unitary Products 37HGBP is standard on all units with VAV and optional with CV units.Economizer Interface OverviewTh
860616-JIM-D-061438 Johnson Controls Unitary ProductsFigure 29: Single Enthalpy Curve And BoundariesEnthalpy SettingsWhen the OA temperature, enthalpy
860616-JIM-D-0614Johnson Controls Unitary Products 39speed by the unit controller. After the delay one of two actions will happen:• The Y2 In call wil
860616-JIM-D-06144 Johnson Controls Unitary ProductsNomenclatureZJJ07 N10 A 2 A AA 6 0 1 2 4 AProduct CategoryZ = A/C, Single Pkg., R-410AC00 = Coolin
860616-JIM-D-061440 Johnson Controls Unitary ProductsCFM Static Pressure and Power-Altitude and Temperature CorrectionsThe information below should be
860616-JIM-D-0614Johnson Controls Unitary Products 41Figure 31: Altitude/Temperature Correction FactorsThe examples below will assist in determining t
860616-JIM-D-061442 Johnson Controls Unitary ProductsDrive Selection1. Determine side or bottom supply duct Application.2. Determine desired airflow.3
860616-JIM-D-0614Johnson Controls Unitary Products 43Table 16: Airflow Performance - Side Duct ApplicationJ06ZJ (6.5 Ton) Side DuctAir Flow(CFM)Availa
860616-JIM-D-061444 Johnson Controls Unitary ProductsJ10ZJ (10 Ton) Side DuctAir Flow(CFM)Available External Static Pressure - IWG11. Blower performan
860616-JIM-D-0614Johnson Controls Unitary Products 45Table 17: Airflow Performance - Bottom Duct ApplicationJ06ZJ (6.5 Ton) Bottom DuctAir Flow(CFM)Av
860616-JIM-D-061446 Johnson Controls Unitary ProductsJ10ZJ (10 Ton) Bottom DuctAir Flow(CFM)Available External Static Pressure - IWG11. Blower perform
860616-JIM-D-0614Johnson Controls Unitary Products 47Air BalanceStart the supply air blower motor. Adjust the resistances in both the supply and the r
860616-JIM-D-061448 Johnson Controls Unitary ProductsMethod Two1. Drill two 5/16 inch holes, one in the return air duct as close to the inlet of the u
860616-JIM-D-0614Johnson Controls Unitary Products 49Supply Air Drive AdjustmentAt unit start-up, the measured CFM may be higher or lower than the req
860616-JIM-D-0614Johnson Controls Unitary Products 5InstallationInstallation Safety InformationRead these instructions before continuing this applianc
860616-JIM-D-061450 Johnson Controls Unitary ProductsOperationCooling Sequence Of OperationFor the J**ZJ series of units, the thermostat makes a circu
860616-JIM-D-0614Johnson Controls Unitary Products 51For units with VFD and VAV control, the unit must first be put into the Occupied Mode to start op
860616-JIM-D-061452 Johnson Controls Unitary Productsmaintain a constant supply air temperature as monitored by the discharge air sensor. If the outdo
860616-JIM-D-0614Johnson Controls Unitary Products 53dampers open; gravity closes the dampers when the exhaust fan is off.Motorized Outdoor Air Damper
860616-JIM-D-061454 Johnson Controls Unitary Productsdown the compressor. The UCB incorporates features to minimize compressor wear and damage. An Ant
860616-JIM-D-0614Johnson Controls Unitary Products 55Electric Heat Anticipator SetpointsIt is important that the anticipator setpoint be correct. Too
860616-JIM-D-061456 Johnson Controls Unitary ProductsFlame SenseFlame sensing occurs at all times. If “W1” is not present and a flame is sensed for 2
860616-JIM-D-0614Johnson Controls Unitary Products 57Flash CodesThe ICB will initiate a flash code associated with errors within the system. Refer to
860616-JIM-D-061458 Johnson Controls Unitary ProductsPost Start ChecklistAfter the entire control circuit has been energized and the heating section i
860616-JIM-D-0614Johnson Controls Unitary Products 59NOTE: To find the Btu input, multiply the number of cubic feet of gas consumed per hour by the B
860616-JIM-D-06146 Johnson Controls Unitary Products3. Gas-Fired Central Furnace Standard, ANSI Z21.47 - Latest Edition4. Local building codes, and5.
860616-JIM-D-061460 Johnson Controls Unitary ProductsAdjustment Of Temperature RiseThe temperature rise (the difference of temperature between the ret
860616-JIM-D-0614Johnson Controls Unitary Products 61Predator® Flash CodesVarious flash codes are utilized by the unit control board (UCB) to aid in t
860616-JIM-D-061462 Johnson Controls Unitary ProductsFigure 36: Unit Control BoardUnit Control Board Option SetupOption Byte Setup• Enter the Option S
860616-JIM-D-0614Johnson Controls Unitary Products 63Table 30: Heat DelayHeat Fan On DelayHeat F an O ff DelayRed LED 8Red
860616-JIM-D-061464 Johnson Controls Unitary ProductsCooling Troubleshooting GuideNOTE: For units with optional VFD without manual bypass, the M3 con
860616-JIM-D-0614Johnson Controls Unitary Products 65out, cancel any call for cooling. This will reset any compressor lock outs.NOTE: While the above
860616-JIM-D-061466 Johnson Controls Unitary Productsremove any call for cooling at the thermostat or by disconnecting the thermostat wiring at the Y2
860616-JIM-D-0614Johnson Controls Unitary Products 67economizer is not providing free cooling. To test the economizer control, disconnect the Mate-N-L
860616-JIM-D-061468 Johnson Controls Unitary Products3. With the draft motor running, check for 24 volts at the pressure switch terminal on the ICB. I
860616-JIM-D-0614Johnson Controls Unitary Products 69Start-Up Sheet1034349-UCL-A-0313START-UP & SERVICE DATA INSTRUCTIONSTART-UP CHECKLISTDate: __
860616-JIM-D-0614Johnson Controls Unitary Products 7LocationUse the following guidelines to select a suitable location for these units:1. Unit is desi
860616-JIM-D-061470 Johnson Controls Unitary Products1034349-UCL-A-03132 Unitary Products GroupSAFETY WARNINGSThe inspections and recording of data ou
860616-JIM-D-0614Johnson Controls Unitary Products 711034349-UCL-A-0313Unitary Products Group 3REFERENCEGeneral Inspection Completed See NotesUnit ins
860616-JIM-D-061472 Johnson Controls Unitary Products1034349-UCL-A-03134 Unitary Products GroupOperating Measurements - Air FlowELECTRICAL DATAT1 - T2
860616-JIM-D-0614Johnson Controls Unitary Products 731034349-UCL-A-0313Unitary Products Group 5OPERATING MEASUREMENTS - COOLINGREFRIGERANT SAFETIESOPE
Subject to change without notice. Printed in U.S.A. 860616-JIM-D-0614Copyright © 2014 by Johnson Controls, Inc. All rights reserved. Supersedes: 86061
860616-JIM-D-06148 Johnson Controls Unitary ProductsUnits may be moved or lifted with a forklift. Slotted openings in the base rails are provided for
860616-JIM-D-0614Johnson Controls Unitary Products 9Figure 8: J06 thru 10ZJ Physical DimensionsTable 3: J06 thru 12ZJ Unit Accessory WeightsUnit Acces
Kommentare zu diesen Handbüchern